Complain about a product or service

Polaris Scrambler, Sportsman ATVs

May 3, 2005
Polaris Industries is recalling selected Sportsman and Scrambler model ATVs because of a problem with the electronic control modules in some units.

Affected by the recall are the following models: Polaris 2004.5 ‘Sportsman 500,’ 2005 ‘Sportsman 400,’ ‘Sportsman 500,’ ‘Sportsman 600,’ ‘Sportsman 700,’ and 2005 ‘Scrambler 500’.

Some 2004.5 and 2005 Model Year Sportsman and 2005 Model Year Scrambler 500 ATVs were assembled with possibly defective Electronic Control Modules (ECM) which may fail and overheat. If this were to occur, excessive heat could cause a fire, possibly resulting in serious injury or death.

Affected units can be verified by comparing the last six digits of the Vehicle Identification Number (VIN) to the serial number range in bold type below. NOTE: Not all 2004.5 and 2005 vehicles are affected. Please review the affected unit table below.

Polaris has received 26 reports of the ECM overheating. No injuries have been reported.

Only select model year Polaris ATVs are part of this recall. The Sportsman ATV model and serial number identification decal is located on the right front side of the front radiator covering. The Scrambler 500 ATV model and serial number identification decal is located on top of the front cab cover. The VIN, or serial number is permanently stamped into the left frame rail behind the left front wheel of all Polaris ATVs.

Polaris dealers sold these ATVs nationwide from August 2004 through February 2005 for between $5,999 and $7,299.

Remedy: Free repair. Contact your Polaris ATV dealer to schedule an appointment for ECM replacement. Polaris has notified registered affected consumers directly about this recall.

Consumer Contact: Call Polaris at (800) 765-2747 between 8 a.m. and 12 midnight ET everyday, or log on to the company’s Web site at www.polarisindustries.com.

The recall is being conducted in cooperation with the U.S. Consumer Product Safety Commission (CPSC).

Back to the top